Transactions of Nonferrous Metals Society of China The Chinese Journal of Nonferrous Metals

您目前所在的位置:首页 - 期刊简介 - 详细页面

中国有色金属学报

ZHONGGUO YOUSEJINSHU XUEBAO

第26卷    第11期    总第212期    2016年11月

[PDF全文下载]    [Flash在线阅读]    [HTML全文阅读]

    

文章编号:1004-0609(2016)-11-2449-12
采用溴代十六烷基吡啶从碱性氰化液中萃取和富集钯、铂
李 荣,张金燕,陈慕涵,吴胜杰,刘 燕,李金飞,黄章杰

(云南大学 化学科学与工程学院,昆明 650091)

摘 要: 对使用溴代十六烷基吡啶(HPB) 作为萃取剂,在碱性氰化液中同时萃取富集钯、铂进行考察,对影响萃取富集效率的各种因素:稀释剂种类、溴代十六烷基吡啶浓度、改性剂用量、相比、萃取时间、水相中Pd(II)和Pt(II)浓度及溶液的pH值进行研究。结果表明:使用溴代十六烷基吡啶浓度为0.05 mol/L,正辛醇含量为30%(体积分数),相比(O/A)为1:5的有机相,在pH=10.5碱性氰化液中,5 min内能将Pd(II)(<70 mg/L)和Pt(II)(<60 mg/L)从水相转移至有机相,采用NH4SCN溶液反萃有机相中的Pd(II)和Pt(II),采用斜率法、红外和紫外光谱分析对萃取机理进行推测,该方法可运用于钯、铂浮选精矿氰化浸出液中Pd(II)和Pt(II)的萃取,富集倍数为15,回收率大于95%。

 

关键字: 碱性氰化液;溴代十六烷基吡啶;钯;铂

Simultaneous extraction and preconcentration of palladium and platinum from alkaline cyanide solution by hexadecylpyridinium bromide
LI rong, ZHANG Jin-yang, CHEN Mu-hang, WU Sheng-jie, LIU Yang, LI Jin-fei, HUANG Zhang-jie

School of Chemical Science and Technology, Yunnan University, Kunming 650091, China

Abstract:Simultaneous extraction and preconcentration of Pd(II) and Pt(II) from alkaline cyanide solution using hexadecylpyridinium bromide(HPB) as extractant were investigated. The factors affecting extraction and preconcentration efficiency, including diluent type, concentration of hexadecylpyridinium bromide, content of modifier, phase ratio (O/A), contact time of aqueous and organic phase, concentrations of Pd(II) and Pt(II) and pH value of solution, were studied. The results indicate that, at concentration of hexadecylpyridinium bromide (HPB) 0.05 mol/L, content of n-octyl alcohol 30% (volume fraction), phase ratio(O/A)=1:5, pH values 10.5 contact time of 5 min, Pd(II)(<70 mg/L) and Pt(II)(<60 mg/L) in alkaline cyanide solution can be transferred from the aqueous phase into the organic phase. Ammonium thiocyanate solution can be used as stripping agent. The extraction mechanism can be deduced based on slope analysis,FTIR spectrum and UV spectrum. The proposed method was applied to extract of Pd(II) and Pt(II) from leaching cyanide liquor of Pt-Pd flotation concentrate. The enrichment factor of 15 is achieved. The recovery rate is high than 95%.

 

Key words: alkaline cyanide solution; hexadecylpyridinium bromide; palladium; platinum

ISSN 1004-0609
CN 43-1238/TG
CODEN: ZYJXFK

ISSN 1003-6326
CN 43-1239/TG
CODEN: TNMCEW

主管:中国科学技术协会 主办:中国有色金属学会 承办:中南大学
湘ICP备09001153号 版权所有:《中国有色金属学报》编辑部
------------------------------------------------------------------------------------------
地 址:湖南省长沙市岳麓山中南大学内 邮编:410083
电 话:0731-88876765,88877197,88830410   传真:0731-88877197   电子邮箱:f-ysxb@mail.csu.edu.cn